Ford Fiesta: Manual Transmission External Controls - 5-Speed Manual Transmission – B5/IB5/6-Speed Manual Transmission – B6 / Gearshift Cable Adjustment - 5-Speed Manual Transmission – B5/IB5. General Procedures
Adjustment
-
Position the gearshift in N position.
-
With the vehicle in N , position it on a hoist.
Refer to: Jacking and Lifting - Overview (100-02 Jacking and Lifting, Description and Operation).
-
Remove the shift cable access cover.
-
Unlock the adjuster.
-
Move the gearshift select cable back and forth and verify free motion.
-
NOTE:
By placing the gearshift lever into the 4th gear position, it locks the small lever into the N position.
Position the gearshifter in 4th gear.
-
Lock the adjuster.
-
Install the shift cable access cover.
-
Install the access hole cover.
-
Install the gearshift housing assembly.
Principles of Operation
Inspection and Verification
Verify the customer concern.
Visually inspect for obvious signs of mechanical damage...
Adjustment
Position the gearshift in N and apply the P brake.
Remove the air cleaner outlet pipe...
Other information:
DTC Charts
DTC Chart: Anti-Lock Brake System (ABS) Module
Diagnostics in this manual assume a certain skill level and knowledge of Ford-specific diagnostic practices. REFER to: Diagnostic Methods (100-00 General Information, Description and Operation)...
Removal
NOTE:
LH side shown, RH side similar.
NOTE:
Removal steps in this procedure may contain installation details.
Remove the check arm bolt.
Torque:
18 lb.ft (25 Nm)
Disconnect the front door electrical connector...
Categories
Special Tool(s) /
General Equipment
Flat Headed Screw Driver
Transmission Jack
Vehicle/Axle Stands
Removal
NOTICE:
Suspension fasteners are critical parts that affect
performance of vital components and systems. Failure of these fasteners
may result in major service expense. Use the same or equivalent parts if
replacement is necessary. Do not use a replacement part of lesser
quality or substitute design. Tighten fasteners as specified.
Remove the floor console.
Refer to: Floor Console (501-12 Instrum
read more